By:丹克on12月24日，2020年

地板洗涤器维护指南：延长机器寿命的提示

自动地板洗涤器可以是一项大投资，因此让您的机器中的大部分寿命都很重要。

Routine maintenance procedures are integral to prolonging machine life and helping you achieve a good return on your investment. Regular maintenance also reduces the likelihood of unplanned equipment downtime due to service or repair needs. Most importantly, you’ll be able to lower service and repair costs that could have otherwise been avoided.

How to Maintain a Floor Scrubber

在本文中，我们将概述应在每次清洁程序之前和之后进行的基本维护程序，使用您的自动地板洗涤器。

汽车地板洗涤器的维护提示：在使用机器之前

Always perform the key tasks below before using your autoscrubber to ensure peak performance.

如果适用，请检查电池

With the exception of someupright floor scrubbers, floor scrubbers run on batteries.

There are four common types of batteries: wet flooded, gel, AGM, or lithium.

Each type of battery has its own specific maintenance requirements, which we review in more detail in this article:地板机电池：您需要了解的一切（类型，维护，成本）。

Regardless of the type of battery, always:

检查以确保电池充电
检查电池端子以确保它们没有腐蚀
确认没有松动的连接
保持湿淹水电池的水位（通常每周）

检查漏极/软管是否有堵塞或泄漏

There should be no debris or cracks in the drain hose or main vacuum hose.

Leftover debris should be removed from the drain and vacuum hose. To backflush the vacuum hose, find the port inside the tank and flush with clean water. This should dislodge any debris.

If there are noticeable cracks or leaks, the hose will need to be replaced.

检查碎片托盘

Clarke SA40碎片捕获笼大多数自动地板洗涤器都有一个碎片捕获托盘内置。碎片托盘旨在保持较小的物品，如包装物，木屑或食物颗粒，在地板上扫描/灰尘扫描程序期间错过了。

虽然碎片托盘应在每次清洁程序结束时清空，但最佳做法是检查以确保托盘在每天使用机器之前空。

剩余的物品可能导致托盘堵塞或溢出。另外，留下碎屑，例如食物颗粒会导致模具和污垢气味。

Maintenance Tips for Auto Floor Scrubbers: After Using Your Machine

Following each floor cleaning procedure, the maintenance steps below should be performed to lower maintenance costs, reduce potential damage, and help you get the most life out of your machine.

Drain Solution and Recovery Tanks

汽车地板洗涤器上有两个独立的坦克;一个用于清洁溶液，一个用于收集从地板上取下的脏溶液。

It is imperative that both of these tanks are emptied at the end of every cleaning procedure.

Chemicals left in the solution tank for too long will become ineffective. Additionally, sometimes when chemicals are left they can gel up and block solution/water flow.

As mentioned earlier, the recovery tank holds the dirty water and chemicals that are removed from the floor.

在程序结束时忘记清空该坦克可以导致坦克中混合的污泥。从地板上除去的沉积物和污垢将沉降并落到回收罐的底部。如果剩余的水干燥，这种混合物将在罐的底部硬化，使您的员工难以去除。

Additionally, this leftover mixture can cause odors that will linger in the tank even after the tanks are cleaned.

冲洗解决方案和恢复罐

在排出这些坦克之后，他们也应该彻底冲洗。冲洗和湿润

G下脏水箱将确保没有剩余的污垢或污垢导致气味。

用盖子打开储存罐

为了减少自动摩擦罐中的模具，霉菌和令人不快的气味，将罐与盖子打开。

This allows air to circulate into the tanks, allowing them to fully dry.

Clean Squeegee Assembly

Squeegees help the autoscrubber remove water and cleaning solution from floors during a cleaning procedure.

The assembly typically has corrosive parts that should be rinsed and wiped after every procedure to reduce rusting and corrosion. AutoScrubber刮刀

刮刀本身也应该被移除，洗净，擦干，有两个原因。第一个是污垢和污垢有时会粘在刮板上，创造线或斑点，因为它被拖到地板上。其次，有不同类型的刮刀刀片，并非全部对化学品和油都具有抵抗力。例如，口香糖叶片不应与油性物质一起使用。

For more on squeegee blade types, check out this article:什么是自动地板洗涤器（类型，尺寸和特色）

如果您注意到刀片明显磨损，请拆下刮刀刀片并翻转刀片。可以使用的刀片通常是四面。一旦使用了刀片的所有四个侧面，它应该更换。

如果全面似乎磨损，请在使用前更换刀片。

如果刀片磨损或撕裂，它将不会有效地从地板上去除水和清洁溶液，这可以为建筑物造成湿滑，危险情况。

Always store the squeegee in the raised position. It should not be resting on the floor as this can cause the blade to become uneven or damaged.

Remove and Clean Floor Pad or Brush

与垫垫司机,应该重新刷moved from the machine so that you can easily access the floor pad or brush.

Pads and brushes are used to scrub the floor of dirt and grime, however after use, dirt can be ingrained in the pad or stuck in the brush bristles.

Thoroughly wash the pad or brush after each use.

Removing excess dirt and debris from the pad or brush will allow the machine to provide the best clean. It will also reduce the chance of cross-contamination between procedures, especially if the machine is being used in different areas or facilities.

如果垫撕裂或过度磨损，请更换垫。

地板或刷子不应存放在地面上。在大多数情况下，这要求您从机器中卸下焊盘驱动器和垫或刷子以进行存储。

Charge the Batteries, if applicable

许多汽车地板洗涤器可配备板载电池充电器。这允许机器在任何120伏的出口处充电。请记住，运行时，机器无法插入车载电池充电器。

小心不要过度收费电池或机会费用。

Pro Tip:充电电池充电是机会fore they reach their minimum charge. Learn more aboutopportunity charging.

只有在整个清洁程序完成后的电池或电池少于推荐的充电容量，通常为20％。

For example, if a battery has a three hour run time, and you are done using the machine after 30-40 minutes it can be safely charged without damaging the battery.

Final Thoughts

With these key maintenance tips, you'll be able to prolong the life of your machine and achieve a better return on your investment.

Regular maintenance requires attention both before and after use.

在清洁程序之前，检查机器是否损坏或任何剩余的碎片。

清洁程序后，彻底清洁机器的磨损部位。不要忘记清洁可能腐蚀与清洁溶液或盐的接触的零件。

EBP and other Imperial Dade locations have the tools, team, and knowledge to keep your equipment in peak condition and prevent surprise breakdowns.

If you're located in the United States, Puerto Rico, or the Caribbean, we can help you maintain your janitorial equipment.Contact an EBP specialist今天讨论最佳实践您的员工可以遵循以保持您的设备以顶部形状运行。